Rising Sun Member Forums  

Go Back   Rising Sun Member Forums > Toyota 4x4 > General Tech Forum

Reply
 
Thread Tools
  #11  
Old 12-10-2006, 02:51 PM
Rezarf's Avatar
Rezarf Rezarf is offline
Hard Core 4+
 
Join Date: Aug 2005
Location: Louisville, CO
Posts: 4,091
Default

Good tips Wes.

I am without a factory manual, but I do have a multimeter. I assume I am looking for obvious drop after start up?

I will run through your list, is sounds like good places to start.

Thanks man, hows the baby?

Drew
__________________
Rezarf <><
My rig... "Maude"
1976 FJ40 with some stuff and some leaks.

1999 UZJ 100 Series bone stock ready to rock AKA:The backup minivan

2012 Toyota Sienna Minivan, fastest Toyota in the stable.

My camping trailer build up thread.

"You 80 guys are just a Sawzall away from nirvana." -Red Chili
Reply With Quote
  #12  
Old 12-10-2006, 03:18 PM
wesintl's Avatar
wesintl wesintl is offline
Hard Core 4+
 
Join Date: Aug 2005
Location: in da house
Posts: 7,595
Send a message via AIM to wesintl
Default

coil -

with both contacts on either side of the coil outlet. (the 2 with wires and nuts)
resistance w/o 2.6-4.0 ohms
w/ 1.3 -1.6 ohms
secondary - in the coil outlet, + on the black wire at coil
w/o 6-9.0 ohm
w/ 9.5 -14.5
external, contacts on the 2 nuts facing out like the coil
1.3-1.7

Ignitor + on the top nut, the one without the black wire going to the coil. turn the key to on and you should have 12v.
__________________
See you on the trail
WREK
Couple o' FJ40's, BJ70, UZJ100, TDI 66FJ40,82FJ60,97FZJ80
TLCA#4180
Reply With Quote
  #13  
Old 12-10-2006, 04:03 PM
Rezarf's Avatar
Rezarf Rezarf is offline
Hard Core 4+
 
Join Date: Aug 2005
Location: Louisville, CO
Posts: 4,091
Default

Thanks Wes!

FWIW, I was out messing with it. Same results from where I left off last night. Starts then immediately dies.

So, I got out and played with the wires a bit, just checking for anything loose at the coil/ignitor, and VAROOOM!

Runs like a champ. I am going to clean all the connections and try the volt meter.

Wes, I really appreciate the info man. Where can I get a FSM?

Thanks!

Drew
__________________
Rezarf <><
My rig... "Maude"
1976 FJ40 with some stuff and some leaks.

1999 UZJ 100 Series bone stock ready to rock AKA:The backup minivan

2012 Toyota Sienna Minivan, fastest Toyota in the stable.

My camping trailer build up thread.

"You 80 guys are just a Sawzall away from nirvana." -Red Chili
Reply With Quote
  #14  
Old 12-10-2006, 05:59 PM
wesintl's Avatar
wesintl wesintl is offline
Hard Core 4+
 
Join Date: Aug 2005
Location: in da house
Posts: 7,595
Send a message via AIM to wesintl
Default

cool, glad it was simple. Spread open the connection on the wire that goes to the coil a tad so it's a nice tight fit.

You can buy the original Factory Service Manual (FSM) at:

Toyota Material Distribution Center
750 West Victoria St
Rancho Dominguez/Compton, CA 90220-5538 USA
1-800-622-2033
(outside CA)(M-F: 7-5 PST)
1-800-443-7656 (inside CA)
1-310-818-4630 (in or outside CA)

The 2f I think you want is pub #98126 (at least the one I havefor my 76)

You can always try ebay and find one of the smaller grey cover books to match the vintage.
http://search.ebay.com/search/search...tSearch=Search
__________________
See you on the trail
WREK
Couple o' FJ40's, BJ70, UZJ100, TDI 66FJ40,82FJ60,97FZJ80
TLCA#4180
Reply With Quote
  #15  
Old 12-10-2006, 09:06 PM
Rezarf's Avatar
Rezarf Rezarf is offline
Hard Core 4+
 
Join Date: Aug 2005
Location: Louisville, CO
Posts: 4,091
Default

Thanks again Wes!

I will be bidding on the manual using my Ebay sniper technique.

Drew
__________________
Rezarf <><
My rig... "Maude"
1976 FJ40 with some stuff and some leaks.

1999 UZJ 100 Series bone stock ready to rock AKA:The backup minivan

2012 Toyota Sienna Minivan, fastest Toyota in the stable.

My camping trailer build up thread.

"You 80 guys are just a Sawzall away from nirvana." -Red Chili
Reply With Quote
Reply

Thread Tools

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -6. The time now is 12:09 AM.


Powered by vBulletin® Version 3.7.1
Copyright ©2000 - 2014, Jelsoft Enterprises Ltd.